KangdaCast is used for orthopedic, which consists of a knitted
fiberglass fabric.Kangdacast is impregnated with water-activated
Introduction：<Look at the catalogue><Upper limb cast operation video ><Upper limb splint operation video
KangdaCast is harder and easier to be cut than KangdaCast Poly.But
KangdaCast Poly is lighter than KangdaCast and can be burnt
thoroughly to be environment friendly.
KangdaCast Poly products have advantages in these characteristics:
lightweight, high strength, radiolucence and porosity comparing
with traditional plaster cast.
Besides, the dust generated by removing the cast is lower in
quantity and larger in particle size than the dust generated upon
the removal of a plaster cast.
Exposure to moisture or water initiates a chemical reaction that
causes the tape to harden.
Specification and Size
1 Excellent X-ray radiolucence
2 High strength
3 Good air-permeability
4 Easy operating
Be careful not to break the package.
Store KANGDA Cast at room temperature.
Damaged products by careless handing cannot be
replaced.Please handle and store them carefully.
The shelf life of KANGDA Cast is 2 years from the day of
1. Put on the padded covering in the affected body part, and twine
with the cotton paper.
2. Wear surgical gloves.
3. Before opening the package, choose the roll of proper size.
4. Immerse the roll in room temperature water for 2-3
seconds and squeeze it 2-3 times.
5. Wrap spirally, overlapping the previous layer by one-half
or two-thirds the width of the roll. Just 3-4 layers provide a
strong non-weight-bearing cast and 5-6 layers are typically
adequate for weight-bearing cast.
6. KangdaCast is sufficiently cured to pervert further
molding in 3-5 minutes after immersion in the water. Allow
about 10 minutes for sufficient cure and let patients do not
move during this time.
7. KangdaCast may be windowed, trimmed or removed with traditional
cast saw equipment.
Please apply the surgical rubber gloves when you operate the
When the resin is stuck to operator, please wipe it out with cotton
swab with acetone.
Recommended Amount of Usage
2in Children’s hands, fingers, and toes
3in Children’s wrists, ankles, and arms and legs
4in Children’s legs and ankles, adult’s hands and wrists
5in Adult’s arms and legs
6in Adult’s arms and legs